bord and pillar mining nveyor methodology

bord and pillar mining nveyor methodology

Mine Details | MiningLink

Moranbah South Mine to use Longwall, Bord and Pillar Methods of Mining Coal from Moranbah South will be mined using bord and pillar andlongwall methods. The run-of-mill coal will be taken by conveyor to aCHPP (coal handling and preparation plant) that will be built on site forcoal processing.

Ask for a quote

MAJOR PROJECT ASSESSMENT Awaba Colliery Mining …

Underground mining at Awaba Colliery is undertaken using bord and pillar and pillar extraction methods. Up to 800,000 tonnes of run of mine (ROM) coal is currently extracted annually for use by Eraring Power Station or for export. The project, known as the Awaba Colliery Mining Project, would allow …

Ask for a quote

EVALUATION OF PILLAR DESIGN SYSTEMS FOR LOW …

2016-6-15 · ensure its safe and economic extraction. The success of a bord and pillar mining method in the exploitation of platinum heavily depends on a comprehensive and competent pillar design method. Pillars need to be large enough to contain load and to be small enough to avoid loss of resource. An optimum pillar design method achieves such a scenario.

Ask for a quote

OPTIMIZATION OF MECHANIZED MINING LAYOUT …

2012-9-5 · These methods are: • Bord and pillar (1.8 m–2.2 m stope widths using low-profile (LP) mechanized equipment) • Breast mining (1.3 m stope width using extra-low profile (XLP) mechanized equipment) A graphical representation of the bord and pillar and mechanized breast mining methods is shown in Figure 1 and Figure 2. It is important to note ...

Ask for a quote

Mine Details | MiningLink

The Myuna Mine Incorporates the Use of a Continuous Miner and Bord and Pillar Technology The Myuna underground mine operates with the use of a Continuous Miner incorporating the Bord and Pillar technology. In 2011 the mine produced 1.58 million tonnes of coal although it has a capacity to produce two million tonnes a year.

Ask for a quote

Underground Mining Methods

2009-12-7 · FIGURE 1.2 Classic room-and-pillar mining this chapter; the goal of this chapter is to summarize briefly the characteristics of the major mining methods. 1.3.2 Room-and-Pillar Mining Room-and-pillar mining is designed for flat-bedded deposits of limited thickness, such as copper shale, coal, salt and potash, limestone, and dolomite.

Ask for a quote

Pillar Strength and Design Methodology for Stone Mines

2012-8-30 · presents a pillar design methodology that was developed from a study of pillar performance in operating stone mines. Data were collected that describe the rock mass quality, pillar conditions, mining dimensions and intact rock strength. The results showed that current mining practices have resulted in generally stable

Ask for a quote

Optimization of Continuous Miner Operations in Bord …

2020-6-18 · Bord and pillar mining The following methods are commonly used in bord and pillar method for development and depillaring using continuous miner: Development 1. Bord and pillar method Depillaring 1. Split and Fender system 2. Nevid method of mining Continuous miner A continuous miner is a large steel drum equipped with a

Ask for a quote

Underground Mining Methods and Technology

Read the latest chapters of Advances in Mining Science and Technology at ScienceDirect , Elsevier''s leading platform of peer-reviewed scholarly literature

Ask for a quote

Mining Methods

2018-3-4 · The demand for high quality coal can be met by adopting underground production methods such as cut-and-fill, bord-and-pillar, shrinkage stopping and longwall coal mining. These methods are supported by highly mechanised equipment. Key among these are continuous miners, longwall mining, load haul dumper and sub-level stoping. Continuous miners

Ask for a quote

Bord & Pillar – Mining Science and Technology

As bord and pillar workings are developed roof support becomes a major consideration and operating cost item. Support requirements vary considerably and are dependent on the physical conditions in the seam, which are often depth dependent, and the length of …

Ask for a quote

continous Miners | Coal, Colliery and Mining Forum.

 · There wasn''t a lot of bord and pillar work in the UK coal mining industry Lannie, mostly longwalls, I dare say the majority of fellers on this site have only been in longwall mining. My first bord and pillar mine was in gypsum, where we drilled the faces with twin boom Secoma rigs and fired down on …

Ask for a quote

Bord-and-pillar mining explained | Illawarra Mercury ...

2017-5-31 · Bord-and-pillar mining is used in first workings of a deposit, and when irregularly shaped deposits, or sensitive environmental conditions, call for a lighter …

Ask for a quote

PREVIOUS AND CURRENT MINING METHODS.

2021-1-29 · Mining method and equipment 4.2.1 General The bord and pillar mining layout will be maintained because of its reliability, flexibility, low capital cost, low working costs and large skills source availability (Woodruff, 1966). Increasing mechanization has resulted in an increasing production in the amount of the fine coal

Ask for a quote

Pillar design in coal mines

2021-1-31 · Fig. 3-Potential areas of application of bord-and-pillar mining It should be noted that both bounds are controlled largely by economic factors. For the most severe con-straints, namely a coal-to-waste ratio of 1:10 and an upper limit for lost coal of 30 per cent, the field of application of conventional bord-and-pillar methods is

Ask for a quote

Mining Methods: Longwall, Horizon and Level Mining …

2021-11-19 · Apart from the commonly practiced "bord and pillar" method of mining followed in this country, the other methods of mining adopted in some collieries are: 1. Longwall Mining Method 2. Horizon Mining 3. Level Mining or Semi-Horizon Mining. Room and pillar method of mining is not practiced in any of the collieries in India though it is the ...

Ask for a quote

A Probabilistic Structural Design

2021-3-26 · typical bord and pillar chrome mine, using the Hedley-Grant equation and the tributary area theory showed the following results: Probability of Failure = 23% at a factor of safety of 1.57. Accepting that the Hedley-Grant equation is correct and that the Tributary Area Theory is a true

Ask for a quote

(PDF) Pillar design in coal mines

 · The paper points out that bord-and-pillar mining is the most important method of coal extraction in South African underground coal mines, and advocates that pillar …

Ask for a quote

(PDF) Pillar design in coal mines

The paper points out that bord-and-pillar mining is the most important method of coal extraction in South African underground coal mines, and advocates that pillar design procedures should be ...

Ask for a quote

Department of Mining Engineering National Institute of ...

2013-11-4 · Bord and pillar method is the most widely practiced underground mining method in India. Nevertheless about 61% of underground coal mining accidents are due to roof and side fall of bord and pillar. Design of systematic support is essential to avoid strata control problem and to provide safe working condition.

Ask for a quote

Bord-and-pillar mining in inclined orebodies | Journal of ...

2003-3-1 · This methodology was then applied in the design of a mechanized bord-and-pillar mining layout for a given piece of ground (Vlakpoort and Moddergat) using a given selection of machines. This piece of ground contains the PGM bearing UG2 Reef with an average thickness of 124 cm and dipping at 18� with adverse strike and dip changes.

Ask for a quote

Design of Bord and Pillar method in coal mines

2016-2-27 · Bord and Pillar method of mining is one of the oldest methods. 3. INTRODUCTION In India, about 98% of underground output of coal is obtained by Bord and Pillar method and barely about 2% by longwall methods. The other countries …

Ask for a quote

(PDF) Success of Continuous Miner in Bord and Pillar …

 · The following methods are commonly used in bord and pillar method for development and ... The cost of mining coal using a room pillar mining method with continuous miner and a longwall mining ...

Ask for a quote

Komatsu develops CM features to facilitate bord and pillar ...

2021-9-14 · Komatsu develops CM features to facilitate bord and pillar mining. KOMATSU has introduced features for its continuous miner and a next-generation conveyor chain to help mines maximise uptime and achieve productivity goals in underground coal mines. A 12HM46 continuous miner operates underground. Underground Mining > Fleet.

Ask for a quote

EVALUATION OF BORD AND PILLAR MINING SYSTEM IN …

2010-5-13 · One of the oldest methods of mining is the Bord and Pillar. It is a method in which the mined material is extracted across a horizontal plane while leaving "pillars" of untouched material to support the overburden leaving open areas or "rooms" underground. It is usually used for relatively flat-lying deposits, such as those that follow a ...

Ask for a quote

VENTILATION PLANNING LAYOUTS FOR LARGE …

2012-8-29 · Standard room-and-pillar mine layouts are used, but can easily be adapted for staggered or elongated pillars. Split-Mine Ventilation Of the three ventilation methods, split-mine ventilation is the simplest in terms of layout and design, as the mine is split …

Ask for a quote

Contact Us